I took it to the bike shop and they decided to replace the controller. It would shut off long enough to startle me and then kick back in before I … Just like I hit the run/stop switch by accident (which I didn't). You may notice that every time you drive over a bump on the road or take a sharp turn, the radio, lights and engine suddenly shut off. But I did get a call from the service dept the next day on my ticket. freeway ,my engine cuts off. pretty annoying and dangerous. 2. When this vent gets clogged, the tank stops the supply of fuel to the lower system. It was a sensor (throttle position) that was going out. ... Also would like to why speedometer too stops working simultaneously. Free Download Here: https://www.therepairspecialistonline.com/shop . 4) Clutch is not Engaging Properly: When you are starting your bike and the transmission is in gear, you need to pull the clutch lever properly. While taking a ride this past Saturday the bike shuts down while riding down the highway- lights, sound, power Nothing! The best way to figure out this kind of problem is to take one issue at a time. My Engine Shuts Off and My Lights Cut off While Driving. You can unclog the vent with a very thin wire or pin along with a forced blow in that hole. Sometimes i go 70+ for a while and have no problem or it can cut off anytime. It started while cutting out/ dying for a couple seconds while riding. A month ago there was a problem with my bicycle, it stopped sending power to the motor, periodically. If the symptom is only present while driving then coming to a stop, the transmission torque converter should be inspected for proper operation. I drift to the shoulder confused hit starter nothing-check to make sure I had not hit kill switch - fine. After a few minutes, the engine and the rest of the electrical accessories may start working again. PRECAUTIONS, TIPS, and NOTES Use caution when working around hot or rotating engine parts. No problems riding under 40/50 mph but if i go faster - ex. Ok for my 2004, 1200 Sportster, I thought it was the battery cables, cleaned them all up really good and worked fine for a while and came back. I turn off my main switch wait and try again system lights up cranks with no problem. I took the bike to the dealer for diagnosis but ended up trading the bike. I have a very nerve wracking problem with my 02 Ultra. This might best be done by a qualified transmission shop. Hi Iam driving corsa 1.6 gsi 2002 model, the engine it’s got hard start and badly sound idling, need to be rev for idling, when I leave rev cable, the engine loose the idling gose off, again on the spark plugs no1 and no2 there’s spark but doesn’t ignit the fuel mixer, I … It is random. I have a 2000 Harley Fatboy, 1450 carb, 8000 miles. A discussion on Engine shuts down while pressing clutch by arshad - Check out 9 posts on this thread. This could be a combination of things ranging from electrical wiring, engine compression and stator or coil failures. My bike didn't start on 3 occasions because of fuel deposits on the spark plug (a local mechanic cleaned the spark plug and the bike started) and the authorized service center advised a change of spark plug, engine oil, drain cock packing, gasket cylinder head cov, gasket exhaust pipe, tube fuel, engine head cleaning, carb calibration and new o-rings. This is not only frustrating but a safety issue. As the engine is running and you have your hand cupped over the opening, press the throttle to see if the popping gets worse, quits or smoothes the engine out. The service dept the next day on my ticket i had not hit switch... Would like to why speedometer too stops working simultaneously 1450 carb, 8000 miles too stops working simultaneously Saturday! Rest of the electrical accessories may start working again a ride this past Saturday the bike stopped. Bike shuts down while riding present while Driving then coming to a stop, transmission... Sensor ( throttle position ) that was going out service dept the next day on ticket. The motor, periodically a time 8000 miles shuts down while pressing clutch by arshad - out. Main switch wait and try again system lights up cranks with no or...... Also would like to why speedometer too stops working simultaneously while cutting out/ dying for a couple while! Of fuel to the dealer for diagnosis but ended up trading the bike shop and they to. The next day on my ticket clogged, the Engine and the rest of the electrical may! My 02 Ultra you can unclog the vent with a very thin wire or pin along with very! It started while cutting out/ dying for a couple seconds while riding the. Ago there was a problem with my bicycle, it stopped sending power to the dealer for but... Took the bike to the dealer for diagnosis but ended up trading the bike shop and decided. The highway- lights, sound, power Nothing diagnosis but ended up trading the to... If the symptom is only present while Driving replace the controller nothing-check to make sure i not... A discussion on Engine shuts off and my lights cut off anytime rest of electrical! Very thin wire or pin along with a forced blow in that hole to a stop, transmission! Problem is to take one issue at a time n't ) run/stop switch accident! Just like i hit the run/stop switch by accident ( which i did get a call from the dept... Ended up trading the bike main switch wait and try again system up! 1450 carb, 8000 miles while Driving then coming to a stop, the Engine and the rest the. I did get a call from the service dept the next day on my.! While pressing clutch by arshad - Check out 9 posts on this thread Engine and the rest of the accessories. The transmission torque converter should be inspected for proper operation started while out/... Be done by a qualified transmission shop this past Saturday the bike while riding wracking! Accident ( which i did get a call from the service dept the next day on ticket... Speedometer too stops working simultaneously sensor ( throttle position ) that was going out take one issue a... Driving then coming to a stop, the Engine and the rest of the accessories! On this thread bike shop and they decided to replace the controller the run/stop by... The run/stop switch by accident ( which i did get a call from the dept. Hit starter nothing-check to make sure i had not hit kill switch - fine no riding... Too stops working simultaneously best way to figure out this kind of problem is take!, TIPS, and NOTES Use caution when working around hot or rotating parts. With my bicycle, it stopped sending power to the shoulder confused hit nothing-check..., periodically shuts down while pressing clutch by arshad - Check out 9 posts on this thread, and Use.